PORTER MFG. & SUPPLY CORP. -- GASGACINCH GASKET SEALER  -- 8040-01-125-4673
<pre>=====================  Product Identification  =====================

Product ID:GASGACINCH GASKET SEALER
MSDS Date:10/02/1989
FSC:8040
NIIN:01-125-4673
Kit Part:Y
=== Responsible Party ===
Company Name:PORTER MFG. & SUPPLY CORP.
Address:2215 NO CHICO AVENUE
City:SOUTH EL MONTE
State:CA
ZIP:91733
Country:US
Info Phone Num:213-283-4968 /818-448-3243
Emergency Phone Num:800-424-9300 (CHEMTREC)
Preparer's Name:LYNN D. GRANT
CAGE:PORTE
=== Contractor Identification ===
Company Name:PORTER MFG. & SUPPLY CORP
Address:2215 NO CHICO AVENUE
Box:City:SOUTH EL MONTE
State:CA
ZIP:91733
Phone:213-283-4968 /818-448-3243
CAGE:PORTE

=============  Composition/Information on Ingredients  =============

Ingred Name:TOLUENE  (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 45-55%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:PETROLEUM NAPHTHA (SOLVENT IS A COMPLEX MIXTURE OF
    PREDOMINATELY C6 TO C9 HYDROCARBONS. THE EXACT COMPOSITION WILL
    VARY)
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 22-27%
Other REC Limits:*VENT AS GUIDELINE)
ACGIH TLV:400PPM (RUBBER SOL-*

=====================  Hazards Identification  =====================

Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Health Hazards Acute and Chronic:ACUTE TOXICITY: OVEREXPOSURE CAN LEAD
    TO CENTRAL NERVOUS SYSTEM DEPRESSION (HEADACHE, DIZZINESS, NAUSEA &
    UNCONSCIOUSNESS). EYE: SHORT TERM LIQUID OR VAPOR CONTACT MAY
    RESULT IN SLIGHT IRRITATION. PRO LONG/REPEAT MAY BE MORE
    IRRITATING. SKIN: PROLONG/REPEAT CONTACT CAN CAUSE DEFATTING &
    DRYING WHICH MAY RESULT IN *
Effects of Overexposure:*SKIN IRRIT & DERMATITIS. INHALE: HIGH CONC &
    PROLONGED EXPOSURE TO LOWER CONC MAY BE SLIGHTLY IRRITATING TO
    MUCOUS MEMBRANES. INGEST: LIQUID INGESTION MAY RESULT IN
    VOMITING-ASPIRATION OF LIQUID INTO	THE LUNGS. THIS MUST BE AVOIDED
    AS LIQUID CONTACT W/LUNGS CAN RESULTING CHEMICAL
    PNEUMONITIS/EDEMA/HEMORRHAGE.

=======================  First Aid Measures  =======================

First Aid:EYE: FLUSH W/WATER FOR 15 MIN. GET MED AID. SKIN: FLUSH
    W/WATER FOLLOWED BY WASHING W/SOAP & WATER. REMOVE CONTAM CLOTHES &
    LAUNDER BEFORE REUSE. FOR PESISTANT IRRIT GET MED AID. INHALE:
    REMOVE TO FRE SH AIR & PROVIDE OXYGEN IF BREATHING ISDIFFICULT.
    GIVE CPR IF NOT BREATHING. GET MED AID. INGEST: DO NOT INDUCE
    VOMITING. IF SPONTANEOUS VOMITING OCCURS KEEP HEAD BELOW HIPS. GET
    MEDICAL AID.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:20.0F,-6.7C
Lower Limits:1
Upper Limits:8
Extinguishing Media:REGULAR FOAM, CO2 AND DRY CHEMICAL
Fire Fighting Procedures:USE SPECIAL SELF-CONTAINED BREATHING
    APPARATUS.
Unusual Fire/Explosion Hazard:ELIMINATE ALL IGNITION SOURCES, VAPORS
    ARE HEAVIER THAN AIR AND MAY TRAVEL ALONG THE GROUND OR MAY BE
    MOVED BY VENTILATION.

==================  Accidental Release Measures  ==================

Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. DIKE AREA
    TO PREVENT RUN-OFF. PUMP LIQUID INTO METAL CONTAINER. COVER ANY
    REMAINING MATERIAL WITH SAND, DIRT, CLAY OR VERMICULITE AND PUT
    INTO METAL CONTAINER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE AT ROOM TEMPERTURES BETWEEN 40F
    AND 100F. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE. STORE
    UPRIGHT. KEEP FROM HEAT AND ALL IGNITION SOURCES.
Other Precautions:AVOID BREATHING OF VAPORS, EYE AND SKIN CONTACT.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:USE APPROVED RESPIRATOR OR GAS MASK.
Ventilation:SUFFICIENT TO KEEP TLV BELOW 100 PPM.
Protective Gloves:SOLVENT RESISTANT TYPE
Eye Protection:USE SPLASH GOGGLES
Other Protective Equipment:WEAR CLOTHING AS REQUIRED TO MINIMIZE
    CONTACT.
Work Hygienic Practices:ALWAYS WASH THOROUGHLY WITH SOAP AND WATER
    AFTER EXPOSURE TO THE SKIN.
Supplemental Safety and Health

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:206F,97C
Vapor Pres:17 @ 60F
Vapor Density:> AIR
Spec Gravity:0.88
Evaporation Rate &amp; Reference:2.1 (BU AC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NEUTRAL OR AMBER COLOR LIQUID, STRONG SOLVENT ODOR
Percent Volatiles by Volume:79.6

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZERS AND ALKALIES.
Stability Condition to Avoid:EXCESS HEAT, SPARKS, OPEN FLAME OR ANY
    SOURCES OF IGNITION.
Hazardous Decomposition Products:BURNING MAY PRODUCE CO2, CO AND
    VARIOUS HYDROCARBONS.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE TO ALL FEDERAL, STATE &
    LOCAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.